RUST-OLEUM CORP -- RUST-O-THANE TINTBASES-BASE COMPONENT, 9408  -- 8010-00N027411
<pre>=====================  Product Identification  =====================

Product ID:RUST-O-THANE TINTBASES-BASE COMPONENT, 9408
MSDS Date:11/11/1987
FSC:8010
NIIN:00N027411
=== Responsible Party ===
Company Name:RUST-OLEUM CORP
Address:11 HAWTHORNE PKWY
City:VERNON HILLS
State:IL
ZIP:60061-1583
Country:US
Info Phone Num:312-367-7700/312-864-8200
Emergency Phone Num:312-367-7700/312-864-8200
Preparer's Name:M.J.S.
CAGE:08882
=== Contractor Identification ===
Company Name:RUST-OLEUM CORP
Address:11 HAWTHORN PARKWAY
Box:City:VERNON HILLS
State:IL
ZIP:60061-1583
Country:US
Phone:847-367-7700
CAGE:08882

=============  Composition/Information on Ingredients  =============

Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA III). VP: 70 @ 20C.
    LEL: 2%.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10-15%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:XYLENE; (XYLOL). VP: 22 @ 20C. LEL: 1.2%.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-10%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:2-HEXANONE, 5-METHYL-; (METHYL ISOAMYL KETONE). VP: 4 @
    20C. LEL: 1%.
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293

Ingred Name:PROPIONIC ACID, 3-ETHOXY-,ETHYL ESTER;
    (ETHYL-3-ETHOXYPROPIONATE). VP: 1.1 @ 20C. LEL: 1%.
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 0-3%
ACGIH TLV:50 PPM (MFR)

Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-35%
Other REC Limits:PEL: 15 MG/M3 (MFR)
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293

Ingred Name:RESP PROT: IS RECOMMENDED. IF AIR-MONITORING DEMONSTRATES
    VAPOR LEVELS BELOW 10 TIMES THE APPLICABLE EXPOSURE (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9: LIMITS, THEN A NIOSH/MSHA APPROVED CHEMICAL
    CARTRIDGE RESPIRATOR (TC23C) MAY BE ACCEPTABLE.
RTECS #:9999999ZZ

Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
    GLYCOL METHYL ETHER ACETATE). VP: 3.7 @ 20C. LEL: 1.5%.
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 10-15%

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HARMFUL IF INHALED. MAY
    AFFECT BRAIN/NERVS SYS CAUSING DIZZ, HDACH, NAUS. RPTD OVEREXP MAY
    LEAD PROGRESSIVELY TO STAG GAIT, CONFUSION, UNCON, COMA. CAUSES
    NOSE/THROAT IRRIT. SKIN/EYE CON TACT: CAUSES EYE/SKIN IRRIT WHICH
    CAN LEAD TO DERMAT W/RPTD OVEREXP. SKIN ABSORPTION MAY POTENTIALLY
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CONTRIBUTE TO OVERALL EXPOSURE.
    INGEST: GI IRRIT, NAUS, VOMIT & DIARR. CHRONIC: REPORTS HAVE SHOWN
    RPTD/PRLNG OCCUP OVEREXP TO SOLV W/PERM BRAIN/NERVS SYS DMG.
    OVEREXP TO XYLOL IN LAB ANIMAL S HAS SHOWN LIVER ABNORM, KIDNEY,
    LUNG,SPLEEN & EYE DMG AS WELL AS ANEMIA. AFFECTS IN HUMANS HAS
    SHOWN (SUPP DATA)
Medical Cond Aggravated by Exposure:CHRONIC LUNG OR BREATHING PROBLEMS.

=======================  First Aid Measures  =======================

First Aid:INHAL:REMOVE FROM EXPOS/RESTORE BRTHG. IF BRTHG DFCLTY
    PERSISTS/OCCURS LATER FROM ACTIVATED PROD, CONSULT MD/HAVE LBL INFO
    AVAIL. EYES:FLUSH IMMED W/LG AMTS OF H*2O FOR AT LST 15 MIN. NOTIFY
    MD. SKIN: WASH AFFECTED AREA W/SOAP/WATER, REMOVECONTAMD CLTHG/WASH
    BEFORE REUSE. INGEST:DO NOT INDUCE VOMIT. KEEP WARM/QUIET & GET MED
    ATTN. ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM PNEUMIT WHICH CAN BE
    FATAL.

=====================  Fire Fighting Measures  =====================

Flash Point Method:SCC
Flash Point:50.0F,10.0C
Lower Limits:SEE INGRED
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
    CHEMICAL OR FOAM).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
    . WATER SPRAY MAY BE INEFTIVE, BUT CAN BE USED TO COOL CLOSED
    CONTRS TO PREVENT PRESS BUILD-UP & (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLOSED. ISOLATE FROM
    HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLOSED CONTRS MAY EXPLODE WHEN
    EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT SURFACES.

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
    AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTYS
    IN BLDG DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS IB FLAMM
    LIQUIDS. CONTRS SHLD BE GROUNDED WHEN POURING.
Other Precautions:DO NOT TAKE INTERNALLY. EMPTY CONTRS MAY BE
    HAZARDOUS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:ACTIVATED PROD GIVES OFF HARMFUL VAPS OF
    ISOCYANATES. DO NOT USE IF YOU HAVE CHRONIC LUNG/BRTHG PROBLEMS OR
    IF YOU HAVE EVER HAD A RXN TO ISOCYANATES! WHERE OVERSPRAY IS
    PRESENT, NIOSH/MSHA APPRVD AIR -SUPPLIED RESPIRATOR (TC19C) (ING 7)
Ventilation:PROVIDE GEN DILUTION OR LOCAL EXHST VENT IN VOL/PATTERN TO
    KEEP TLV OF HAZARDOUS INGREDIENTS BELOW ACCEPTABLE LIMITS.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
FIRE FIGHT PROC: POSS AUTOIGNIT/EXPLOS. IF WATER IS USED, FOG NOZZ ARE
    PREFERRED. EFTS OF OVEREXP: LIVER/CARDIAC ABNORM. OVEREXP TO METHYL
    ETHYL KETONE IN LAB ANIMALS HAS ALSO SHOWN LIVER ABNORM, KIDN
    EY/LUNG DMG. FETOTOXIC/EMBRYOTOXIC EFTSFROM INHAL HAVE BEEN SEEN IN
    RATS EXPOSED TO >1000PPM DURING GESTATION.

==================  Physical/Chemical Properties  ==================

HCC:F3
Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.0-1.35 
Evaporation Rate &amp; Reference:SLOWER (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:48-55

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY OPEN FLAME: CARBON MONOXIDE AND
    CARBON DIOXIDE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.